Schulke.co.uk

SAFETY DATA SHEET (91/155/EEC - 2001/58/CE - ISO 11014-1) SAFETY DATA SHEET
1 - IDENTIFICATION OF THE SUBSTANCE/PREPARATION AND OF THE COMPANY/UNDERTAKING
Identification of the substance or preparation:
Name: GIGASEPT ONCE - ADDITIVEProduct code: 1830000 Company/undertaking identification:
Registered company name: Schülke & Mayr UK Ltd.
Address: Cygent House 1 Jenkin Rd Meadowhall.Sheffield S9 1AT.UK.
Telephone: + 44 (0)114 254 35 00. Fax:+ 44 (0)114 254 35 01. Telex:.
[email protected] Emergency telephone: + 33 (0)1 45 42 59 59.
Use of the substance/preparation:
Disinfection of endoscopes.
To be used mixed with the base (direct dilution of the 2 products by the automaton).
2 - COMPOSITION/INFORMATION ON INGREDIENTS
Full text of risk phrases appearing in section 2: see section 16.
Hazardous substances present on their own:
(present in the preparation at a sufficient concentration to give it the toxicological characteristics it would have in a 100% pure state)INDEX 603-117-00-0 CAS 67-63-0 CE 200-661-7 PROPAN-2-OL | Concentration >=25.00% and <50.00%. Symbol: Xi F R: 11-36-67 Other substances representing a hazard:
CAS 2605-79-0 CE 220-020-5 N,N-DIMETHYLDECYLAMINE N-OXIDE | Concentration >=0.00% and <2.50%. Symbol: Xi R: 38-41 Substances present at a concentration below the minimum danger threshold:
CAS 95-14-7 CE 202-394-1 1,2,3-BENZOTRIAZOLE | Concentration >=2.50% and <10.00%. Symbol: Xn R: 52/53-36-20/22 Other substances with occupational exposure limits:
No known substance in this category present.
3 - HAZARDS IDENTIFICATION
This product is classed: Flammable.
Possibility of irritation to the eyes.
Vapors may cause drowsiness and dizziness.
4 - FIRST AID MEASURES
As a general rule, in case of doubt or if symptoms persist, always call a doctor.
NEVER induce swallowing in an unconscious person.
Reminder: any unconscious person must be placed in the lateral recovery position.
In the event of exposure by inhalation:
Move the person away from the place of exposure and take him/her outside.
In the event of respiratory problems (e.g. heavy coughing):Put the person in a half-seated position, with the torso raised ; keep the person warm and calm.
Call a doctor immediately.
In the event of splashes or contact with eyes:
If applicable, remove contact lenses.
Wash thoroughly with soft clean water for 15 minutes, holding the eyelids open.
If there is any redness, pain or visual impairment, consult an ophthalmologist. Show this container or label.
In the event of splashes or contact with skin:
Remove all contaminated or stained clothing immediately. Do not use them again until they have been decontaminated.
Rinse immediately and thoroughly with water.
In the event of skin irritation, seek medical advice. Show this container or label.
In the event of swallowing:
Rinse out the mouth, do not induce vomiting, keep the person calm and take him/her to a clinic or a doctor’s. Show the container or label.
Made under licence of European Label System, Software of INFODYNE (http://www.infodyne.fr) Quick-FDS [14754-57085-29531-709787] - 2008-05-23 - 15:51:27 SAFETY DATA SHEET (91/155/EEC - 2001/58/CE - ISO 11014-1) 5 - FIRE-FIGHTING MEASURES
Chemical powders, carbon dioxide and other extinguishing gas are suitable for small fires.
Move any flammable materials away from the fire.
Suitable extinguishing media:
Special foams for polar liquids (known as alcohol resistant), powders, carbon dioxide.
Extinguishing media which must not be used for safety reasons:
Sometimes, and due to the presence of organic material, a fire may produce a thick black smoke. Exposure to decomposition products may behazardous to health.
Do not breathe in smoke.
Prevent the effluent of fire-fighting measures from entering drains or waterways.
Special protective equipment for fire-fighters:
Fire-fighting personnel are to be equipped with autonomous insulating breathing apparatus.
Full protective suit.
6 - ACCIDENTAL RELEASE MEASURES
Personal precautions:
Avoid inhaling the vapors.
Avoid any contact with the skin and eyes.
Consult the safety measures listed under headings 7 and 8.
Keep away any unprotected person.
Move all flammable sources out of danger and keep them away from the scene.
Eliminate any possible source of ignition and ventilate the premises.
Environmental precautions:
Contain and control the leaks or spills with non-combustible absorbent materials such as sand, earth, vermiculite, diatomaceous earth in drumsfor waste disposal.
Prevent any material from entering drains or waterways.
Use drums to dispose of waste recovered in accordance with applicable regulations (see heading 13).
If the product contaminates waterways, rivers or drains, alert the relevant authorities in accordance with statutory procedures Methods for cleaning up:
Absorb any spilled product with absorbent non-combustible materials, and sweep away or remove with a shovel. Put any waste in drums fordisposal. Do not mix with any other waste. Wash the contaminated surface thoroughly with water.
Do not collect the product for re-use.
7 - HANDLING AND STORAGE
The regulations relating to storage premises apply to workshops where the product is handled.
Handling:
Prevent the formation of flammable or explosive concentrations in air and avoid vapor concentrations higher than the occupational exposurelimits.
Product for external use - do not swallow.
Avoid all contact with skin or eyes.
Do not mix with any other product than the ones dedicated to the solution activation.
Handle in accordance with user instructions on label Fire prevention:
Use the product in premises where there are no naked flames or other sources of ignition and have protected electrical equipmentKeep packages tightly closed and away from sources of heat, sparks and naked flames.
Do not use tools which may produce sparks. Do not smoke.
Prevent access by unauthorised personnel.
Recommended equipment and procedures:
For personal safety, see §8.
Observe precautions stated on label and also industrial safety regulationsAvoid inhaling vapors.
Avoid contact of product with the eyesEye bath and water point nearby.
Storage:
Made under licence of European Label System, Software of INFODYNE (http://www.infodyne.fr) Quick-FDS [14754-57085-29531-709787] - 2008-05-23 - 15:51:27 SAFETY DATA SHEET (91/155/EEC - 2001/58/CE - ISO 11014-1) Keep in the original container only, in a cool and well-ventilated place, away from all sources of ignition, heat and direct sunlight.
Recommended storage temperature: from +5°C to +25°C.
Do not use after the expiry date mentioned on the packaging.
Keep out of the reach of children Specific use(s):
For professional use onlyRefer to paragraph 1 for product indication 8 - EXPOSURE CONTROLS/PERSONAL PROTECTION
Use personal protection equipment as per Directive 89/686/EEC.
The information in this chapter refers to the product specifically described in this document. If the product is handled and/or exposedsimultaneously with other chemical agents, these must be taken into consideration when choosing personal safety equipment.
The Exposure Threshold Limit Value and the Average Exposure Value given below are quoted by the CAS number of the substance. Paragraph 3details the chemical name corresponding to the CAS number.
Technical measures:
Ensure the rooms are well-ventilated. Atmospheric concentrations at the workplace must not exceed the limit values given for normal conditionsof use.
Exposure limit values per INRS ED 984:
Exposure limit values (2003-2006):
Respiratory protection:
Not applicable in normal conditions of use.
In case of insufficient ventilation, with the risk of exceeding the TLVs (Treshold Limit Values)/TWA, wear suitable breathing apparatus.
Use Type A2B2P3 filtres.
Hand protection:
When handling this product, wear suitable gloves.
Butyl or nitrile gloves are recommended.
Gloves must be replaced immediately if they show signs of wear and tear.
Eye and face protection:
Avoid contact with eyes.
Wear safety goggles.
Provide eye washes in workshops where the product is constantly handledWater source nearby.
Skin protection:
For further information, see § 11 of S.D.S. - Toxicological information.
HEALTH MEASURES:Do not eat, drink or smoke during use.
Made under licence of European Label System, Software of INFODYNE (http://www.infodyne.fr) Quick-FDS [14754-57085-29531-709787] - 2008-05-23 - 15:51:27 SAFETY DATA SHEET (91/155/EEC - 2001/58/CE - ISO 11014-1) Wash hands each time after handling.
After each use, systematically wash all personal protective equipment.
9 - PHYSICAL AND CHEMICAL PROPERTIES
General information:
Important health, safety and environmental information:
When a pH measure is possible, it has a value of: 23°C. < Flash point: <= 55°C.
Other information:
Decomposition point/decomposition range : 10 - STABILITY AND REACTIVITY
The preparation is stable at the handling and storage conditions recommended per § 7 of the safety data sheet, Conditions to avoid:
Avoid exposure to heatDo not mix with other products except those defined for use.
Hazardous decomposition products:
At high temperatures, dangerous decomposition products may be produced, such as fumes, carbon dioxide and carbon monoxide, nitrogen oxide.
11 - TOXICOLOGICAL INFORMATION
In the event of exposure by inhalation:
Inhalation may lead to irritation of the respiratory tracts.
Risk of drowsiness and dizziness.
In the event of swallowing:
Ingestion may lead to irritation of the digestive system, abdominal pain, headaches and nausea.
In the event of splashes or contact with skin:
Possibility of itching with light to moderate local redness.
In the event of splashes or contact with eyes:
Ocular irritation: notably redness of the conjonctiva and lacrimation.
12 - ECOLOGICAL INFORMATION
No ecological data on the product itself is available.
The product must not be allowed to run into drains or waterways.
In accordance with Directive 2006/8/EC:
The classification of this preparation takes account of the modifications introduced by Directive 2006/8/EC 13 - DISPOSAL CONSIDERATIONS
The packages must not be reused.
Do not pour into waterways.
Recycle or discard in accordance with the legislation in force, preferably by a collector or an approved company.
Do not contaminate the ground or the water with waste, do not discard waste into the environment.
Made under licence of European Label System, Software of INFODYNE (http://www.infodyne.fr) Quick-FDS [14754-57085-29531-709787] - 2008-05-23 - 15:51:27 SAFETY DATA SHEET (91/155/EEC - 2001/58/CE - ISO 11014-1) Soiled packaging:
Completely empty the container. Keep the label(s) on the container.
Hand over to an approved disposal contractor.
Codes of wastes (Decision 2001/573/EC, Directive 2006/12/EEC, Directive 94/31/EEC on hazardous waste) :
18 01 06 * chemicals consisting of or containing dangerous substancesFor information :18 = Wastes from human or animal health care and/or related research (except kitchen and restaurant wastes not arising from immediate healthcare) 14 - TRANSPORT INFORMATION
Transport product in compliance with provisions of the ADR for road, RID for rail, IMDG for sea and ICAO/IATA for air transport (ADR 2005 -IMDG 2004 - ICAO/IATA 2005).
UN1993=FLAMMABLE LIQUID, N.O.S.
(propan-2-ol) 15 - REGULATORY INFORMATION
This preparation was classified in compliance with the directive known as <All preparations> 1999/45/EC and its adaptationsIn addition directive 2004/73/EC with the 29° adaptation of directive 67/548/EEC (Hazardous substances) have been taken into account.
Preparation classification:
Particular hazards associated with the preparation and safety recommendations:
Vapours may cause drowsiness and dizziness.
In case of contact with eyes, rinse immediately with plenty of water and seek medical advice.
Keep away from sources of ignition - No smoking.
If swallowed, seek medical advice immediately and show this container or label.
16 - OTHER INFORMATION
Since the user's working conditions are not known by us, the information supplied on this safety data sheet is based on our current level ofknowledge and on national and community regulations.
It is at all times the responsibility of the user to take all necessary measures to comply with legal requirements and local regulations.
The information given on this safety data sheet must be regarded as a description of the safety requirements relating to our product and not aguarantee of its propertiesIt is recommended that the information contained in this safety data sheet is provided to the users, if necessary in an appropriate form.
Made under licence of European Label System, Software of INFODYNE (http://www.infodyne.fr) Quick-FDS [14754-57085-29531-709787] - 2008-05-23 - 15:51:27 SAFETY DATA SHEET (91/155/EEC - 2001/58/CE - ISO 11014-1) This information relates to the specifically designated product and may not be valid in combination with any another product. The product mustnot be used for applications other than those specified in heading 1 without having first obtained written handling instructions.
Full text of risk phrases appearing in section 2:
Harmful by inhalation and if swallowed.
Harmful to aquatic organisms, may cause long-term adverse effects in the aquatic environment.
Vapours may cause drowsiness and dizziness.
Made under licence of European Label System, Software of INFODYNE (http://www.infodyne.fr) Quick-FDS [14754-57085-29531-709787] - 2008-05-23 - 15:51:27

Source: http://www.schulke.co.uk/media/64/64-gigasept-once-add.pdf